Engine Design
Show/hide table
Illustration 1 | g01357763 |
Cylinder and valve location (A) Inlet valve (B) Exhaust valve |
Bore ... 94 mm (3.70 inch)
Stroke ... 120 mm (4.72 inch)
Displacement ... 3.3 L (203 in3)
Cylinder arrangement ... In-line
Type of combustion
- Naturally aspirated engines ... Indirect injection
- Turbocharged engines ... Direct injection
Compression ratio
- Naturally aspirated engines ... 22:1
- Turbocharged engines ... 19:1
Number of cylinders ... 4
Valves per cylinder ... 2
Valve lash
- Inlet valve ... 0.25 mm (0.0098 inch)
- Exhaust valve ... 0.25 mm (0.0098 inch)
Firing order ... 1, 3, 4, 2
Fuel injection timing ... 5° BTC
When the crankshaft is viewed from the flywheel end of the engine, the crankshaft rotates in the following direction: ... Counterclockwise
When the camshaft is viewed from the flywheel end of the engine, the camshaft rotates in the following direction: ... Counterclockwise
Note: The left side and the right side of the engine are viewed from the flywheel end. The No. 1 cylinder is the front cylinder.
Caterpillar Information System:
3500 Industrial Engines Stub Shaft (Front)
EMCPII+ for Gas Engines Engine/Generator Programming OP5-0
G3500B Engines Vibration Damper
3034 Engine for Caterpillar Built Machines Crankshaft - Install
3034 Engine for Caterpillar Built Machines Pistons and Connecting Rods - Remove - Serrated Connecting Rod
3412 Generator Set Engines Disconnect Switch
3500B Marine Engines Engine Speed/Timing Sensor - Calibrate
G3500 Engines Junction Box
3034 Engine for Caterpillar Built Machines Pistons and Connecting Rods - Remove - Fractured Connecting Rod
G3500B Engines Fuel Lines
C9 Marine Engines and C9 Marine Generator Sets Cylinder Head - Install
UPS 250, UPS 300, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supply Component Location - Cabinet (SMS)
C11, C13 and C15 On-highway Engines Excessive Black Smoke
3406E, C-10 and C-12 On-highway Engines Excessive White Smoke
3126B and 3126E On-highway Engines Can Not Reach Top Engine RPM
3126B and 3126E On-highway Engines Can Not Reach Vehicle Speed Limit
3126B and 3126E On-highway Engines ECM Will Not Accept Factory Passwords
C11, C13 and C15 On-highway Engines Engine Misfires, Runs Rough or Is Unstable
3406E, C-10 and C-12 On-highway Engines Driver Questionnaire Response
C7 and C9 On-Highway Engines Engine Cranks but Will Not Start
C11, C13 and C15 On-highway Engines Intermittent Low Power or Power Cutout
C11, C13 and C15 On-highway Engines Low Power/Poor or No Response to Throttle
C11, C13 and C15 On-highway Engines Poor Acceleration or Response
320B, 320B L and 320B N Excavators Cooling System Coolant Sample (Level 2) - Obtain