Flywheel - Remove
Show/hide table
所需工具 | |||
---|---|---|---|
工具 | 零件号 | 零件描述 | 数量 |
A | FT-1341 | 托架组件 | 1 |
1B-3623 | 螺栓 | 2 | |
B | FT-1342 | 导向螺栓 | 2 |
C | 138-7575 | 连杆支架 | 1 |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
- 拆下用来固定飞轮的六条螺栓 (1)。
- 通过安装工具 (A) 固定曲轴齿轮。
- 拆下剩余的螺栓 (1)。
Show/hide table
图 2 g00578444 典型示例 - 安装工具 (B)。
Show/hide table
图 3 g00578445 典型示例。 工具 (C) 不是表格中提到的工具。 - 将工具 (C) 固定到起重机上,并将工具定位到飞轮 (2) 的凹槽内。
- 将飞轮 (2) 拉到工具 (A) 上。
- 拆下工具 (A)。
- 利用工具 (C) 拆下飞轮 (2)。
飞轮的重量约为
78 kg (172 lb) 。 - 必要时,将齿圈从飞轮 (2) 上拆下。
Show/hide table
图 1 | g00578443 |
典型示例 |
Caterpillar Information System:
611 Wheel Tractor-Scraper Wheel Tractor-Scraper Power Train Wheel Bearings - Adjust
994D Wheel Loader Power Train Auxiliary Drive Shaft - Install
D11R Track-Type Tractor Refrigerant Dryer - Replace
D11R Track-Type Tractor Air Conditioner In-Line Dryer - Inspect
D8R Track-Type Tractor Air Conditioner In-Line Dryer - Replace
3114, 3116 and 3126 Industrial, Marine and Generator Set Engines Fuel Transfer Pump
3176C and 3196 Engines for Caterpillar Built Machines Inlet Manifold Pressure - Test
994D Wheel Loader Power Train Auxiliary Drive Shaft - Remove
994D Wheel Loader Engine Supplement Fuel Transfer Pump - Remove and Install
D8R Track-Type Tractor Air Conditioner In-Line Dryer - Inspect
3034 Engine for Caterpillar Built Machines Crankshaft Rear Seal - Remove
D10R Track-Type Tractor Model Specific Coolant Information
854G Wheel Dozer Seat
3003, 3013, 3014 and 3024 Engines for Caterpillar Built Machines Flywheel - Remove
963C Track-Type Loader Power Train Pump Drive - Install
3034 Engine for Caterpillar Built Machines Exhaust Manifold - Remove and Install
D10R Track-Type Tractor Indicators and Gauges - Test
3408E and 3412E Engines for Caterpillar Built Machines Flywheel - Install
D11R Track-Type Tractor Indicators and Gauges - Test
D10R Track-Type Tractor Fuses and Circuit Breakers - Replace/Reset
613C Series II Wheel Tractor-Scraper Changing Direction and Speed
D6R Series II Track-Type Tractor Hydraulic System Hydraulic Pump - Piston
D11R Track-Type Tractor Fuses and Circuit Breaker - Replace/Reset
D7R Series II Track-Type Tractor Hydraulic System Ripper Tip Control Valve