1981/06/29 Caterpillar


New Inlet And Exhaust Valves And Valve Guides Have Tighter Fit To Prevent Corrosion And Guide Wear{1104,1105,1101,1103,1108,1109}

Usage:


D8, D9 Tractors;
583, 594 Pipelayers;
D353, D379, D398, D399 Industrial And Marine Engines

SUPPLEMENT: 08/31/81

SERVICE MAGAZINE, JUNE 29, 1981, PAGE 12. In the article "New Inlet And Exhaust Valves And Valve Guides Have Tighter Fit To Prevent Corrosion And Guide Wear," the diameter of the stem for the new valve is wrong. Change the first sentence in the second paragraph to:

"The new valves have smaller, 9.441 mm (.3717") diameter stems."

Also, add "*50V5990" under "First Used", across from "D8" in Chart A.

--------------- END SUPPLEMENT ---------------

Reference: Put a mark through the March 16, 1981, SERVICE MAGAZINE article, "New Inlet And Exhaust Valves And Valve Guides Have Tighter Fit To Prevent Corrosion And Guide Wear," on Page 4, and make reference to this article. This article has the information given in the earlier article, and it has some new information that has become available.

Description of Change: New inlet and exhaust valves and valve guides are used in the above products.

The new valves have smaller, 9.441 mm (.3717") diameter stems. The new valve guides have thread-like grooves inside their bores.

Used together, the new valves and valve guides have a tighter fit than the former valves and guides. The tighter fit keeps combustion gases out of the area between the valves and valve guides.

Formerly, a valve with a 12.7 mm (.500") diameter stem was used. It was possible for combustion gases to get in between the valves and guides. These gases caused corrosion which then caused the guides to wear rapidly. The rate of corrosion and wear is increased when high sulfur fuel is used.

Adaptable To: The new parts are in effect with the Serial Numbers given in Chart A under "First Used." The new parts, used together, are adaptable to all products given in Chart A under "Adaptable To".

Chart B has the parts for installation in D9 Tractors, 594 Pipelayers, and D353, D379, D398 and D399 Industrial and Marine Engines. Chart C has the parts for installation in D8 Tractors and 583 Pipelayers. Chart D has the service head assemblies which are available with the new valves and guides.

The guides must have 0.038 mm (.0015") clearance. Some guides will have to be machined; other guides will not. For clearance checks, the valve stem is to be measured about 115 mm (4.50") from the keeper end.


NOTICE

The clearance between the valve and valve guide has an effect on the service life of the valve guide. It is necessary to have the correct clearance to stop the movement of combustion gases and the corrosion and wear which are the results.


Use the 1P7451 Valve Guide Honing Group and 5P8615 Honing Oil to get the final clearance, if necessary. The complete procedure for use of the 1P7451 Valve Guide Honing Group is given in Special Instruction, Form No. SMHS7526.

Use the 1P7430 Valve Guide Driver Assembly and the 2P2313 Valve Guide Driver Bushing to install the valve guides to the correct depth in heads for D9 Tractors, 594 Pipelayers, and D353, D379, D398 and D399 Industrial and Marine Engines. For those shops that do not have these tools, the tops of the valve guides must be 44.45 ± 0.50 mm (1.75 ± .019") above the machined surface around the valve guide hole.

For D8 Tractors and 583 Pipelayers, use the 1P7430 Valve Guide Driver Assembly and the 5P1727 Valve Guide Driver Bushings to install the guides to the correct depths. The tops of the guides must be 42.93 ± 0.50 mm (1.690 ± .019") above the machined surface around the valve guide holes.

Caterpillar Information System:

1981/06/29 New Gasket Used In Front Housing Group{1166,1162,1151}
1981/06/29 Ring Now Used To Hold Bearing In Auxiliary Drive Group{1165}
1981/06/22 Larger Air Cleaner Used For Less Restriction To Air Flow{1051}
1981/06/22 Cylinder Liners Can Now Be Reconditioned Automatically{0664,0674,1216}
1981/06/22 6V3145 Leveler Now Available{0644}
1981/06/15 Plastic Cases Now Available For Electronic Testing And Diagnostic Equipment{0630,0650}
1981/06/15 Procedure To Stop Lubricant Leakage From Flexible Couplings{3252}
1981/06/08 Remanufactured Clutch Plates Available For Power Shift Transmissions{3155,0375}
1981/06/08 Troubleshooting Water In Shut-Off Solenoid Housing{1259}
1981/06/08 Inspect Piston Skirts During Engine Overhaul Procedures{1214,1213}
1981/06/01 Hardened Nuts And Higher Torque Now Used In Ahead And Astern Clutch Groups{3302}
1981/06/01 New Service Meter Used In Mechanical Shutoff Group{7478}
1981/06/29 Use 6V4828 Snap Ring Pliers To Remove Snap Rings From Turbocharger Housing{0610,1052}
1981/06/29 New Gasket Used For End Cover On Inlet Manifold{1058}
1981/06/29 Tube Added To Prevent Air Leakage In Pressure Regulator{3012,3165,3166,3186}
1981/06/29 Some Parts Books And Microfiche Show Wrong Governor And Fuel Pump Drive Groups For Specific Engines{1288,0374}
1981/07/06 6V3176 Relief Valve Available For Center Hole Double Acting Hydraulic Cylinders{0623}
1981/07/06 New Turbocharger, Turbocharger Oil Line And Aftercooler Air Lines Group Used{1052}
1981/07/06 Mailing Of Engine News And Truck Engine News Microfiche Libraries{0374}
1981/07/06 All Size Identification Marks On Engine Bearings Are Now Shown In Millimeters{1000,1230,1219,1203}
1981/07/06 New Retainers Used To Hold Oil Pump Output Tube In Manifold{3314}
1981/07/06 Single Connector Prevents Leakage From Fuel Filter Lines Groups{1274,1262}
1981/07/06 Stronger Fitting Used With Sending Unit For Oil Pressure Gauge{7457,7451,3310,3314}
1981/07/06 Use 6V4068 Tool Group To Machine Camshaft Thrust Face{0663,1253}
Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.