Fuel System Primary Filter (Water Separator) Element - Replace
Show/hide table
 |
|
Cedera atau bahkan kematian dapat terjadi akibat kelalaian dalam mematuhi prosedur berikut. Bahan bakar yang bocor atau tertumpah pada permukaan yang panas atau pada komponen listrik dapat menyebabkan kebakaran. Bersihkan semua kebocoran atau tumpahan bahan bakar. Jangan merokok sambil bekerja pada sistem bahan bakar. Putar sakelar pemutus hubungan baterai ke posisi OFF atau lepaskan sambungan baterai sewaktu mengganti filter bahan bakar. |
Show/hide table
| PERHATIAN |
|---|
|
Jangan mengisi filter bahan bakar dengan solar sebelum memasangkan filter ini. Bahan bakar ini tidak akan difilter dan dapat terkontaminasi. Bahan bakar yang terkontaminasi akan menyebabkan keausan dipercepat terhadap komponen-komponen sistem bahan bakar. |
Filter primer/separator air terletak di belakang pintu akses di sisi kanan alat berat.
- Buka pintu akses belakang di sisi kanan alat berat.
Show/hide table
Ilustrasi 3 g06394979 Separator air filter primer
(1) Dudukan filter
(2) Rumah filter
(3) Katup kuras
(4) Sensor - Putar katup kuras (3) berlawanan arah jarum jam untuk membuka. Katup kuras terletak di bagian bawah separator air.
Catatan: Untuk informasi mengenai penampungan tumpahan cairan, lihat Buku Petunjuk Pengoperasian dan Perawatan, "Informasi Umum Mengenai Keadaan Bahaya".
- Kuras air dan sedimen ke dalam wadah yang sesuai.
Catatan: Buang semua cairan bekas sesuai dengan peraturan setempat.
- Tutup katup kuras (3).
- Putuskan sensor air (4) dari rangkaian kabel.
Catatan: Jangan mencoba melepaskan mangkuk sedimen dari rumah. Mangkuk sedimen terpasang secara permanen ke rumahnya. Mencoba melepaskan mangkuk sedimen dapat merusak mangkuk.
- Lepaskan rumah filter (2) dan lepaskan filter primer. Kunci pas filter dapat digunakan untuk melonggarkan rumah filter. Buang filter bekas dengan benar.
- Bersihkan dudukan pemasangan (1).
- Lumasi seal pada filter yang baru dengan bahan bakar diesel yang bersih.
- Pasang filter baru ke dalam rumah filter.
- Kencangkan rumah filter kira-kira 1/6 putaran. Jangan gunakan perkakas untuk mengencangkan rumah filter ke alas filter.
- Pastikan sensor (4) berada di posisi yang benar dan sambungkan ke rangkaian kabel. Jika sensor dilepaskan dari mangkuk, pasang sensor dan kencangkan hingga
2.5 ± 0.5 N·m (22 ± 4 lb in) . - Buka katup pemutus bahan bakar.
- Tutup pintu akses.
Show/hide table
| |
| Ilustrasi 1 | g06394899 |
Show/hide table
| |
| Ilustrasi 2 | g06394897 |
Caterpillar Information System:
Event Identification Number (EID) Above 60000 is Now Used on All Cat® Products {1400} Event Identification Number (EID) Above 60000 is Now Used on All Cat® Products {1400}
313 and 313 GC Excavator Fuel Tank Shutoff and Drain Control
G3500H Generator Set Engine Nitrogen Oxide Level - Test
The 160-8178 Connecting Rod Pin End May Fail on Dealer Reconditioned or Reused Connecting Rods for Certain 3412 Engines {1225} The 160-8178 Connecting Rod Pin End May Fail on Dealer Reconditioned or Reused Connecting Rods for Certain 3412 Engines {1225}
G3500H Generator Set Engine Speed Control - Test
New Prelubrication Oil Pump Group is Now Used on Certain 3516 Engines {1319} New Prelubrication Oil Pump Group is Now Used on Certain 3516 Engines {1319}
Procedure for Paralleling XQ230 Generator Sets {4450, 4492, 7451} Procedure for Paralleling XQ230 Generator Sets {4450, 4492, 7451}
New Engine Software Is Used for Certain C9.3 Marine Engines {7432} New Engine Software Is Used for Certain C9.3 Marine Engines {7432}
Improved Rear Cover Assemblies and Air Filter Supports Are Now Used for Certain 3500 60 Hz Generator Sets {726A} Improved Rear Cover Assemblies and Air Filter Supports Are Now Used for Certain 3500 60 Hz Generator Sets {726A}
C7.1-XQ230 Rental Generator Set Engine Air Cleaner Element - Replace
C7.1-XQ230 Rental Generator Set Coolant Sample (Level 1) - Obtain
Updated Flywheel Housing is Now Used on Certain C7 Powered Engines {1156, 1157} Updated Flywheel Housing is Now Used on Certain C7 Powered Engines {1156, 1157}
313 and 313 GC Excavator Engine Oil and Filter - Change
PM620 and PM622 Cold Planer Maintenance Interval Schedule
A Tee with an Orifice is Now Used with the Left-Hand Simplex Fuel Lines on Certain C9.3 Marine Engines {1250, 1274} A Tee with an Orifice is Now Used with the Left-Hand Simplex Fuel Lines on Certain C9.3 Marine Engines {1250, 1274}
Oil Screens May Crack and Degrade on Certain C175 Commercial Engines {1151, 1162, 1206} Oil Screens May Crack and Degrade on Certain C175 Commercial Engines {1151, 1162, 1206}
New Engine Software for Certain C4.4 Machine Engines {7610, 7620} New Engine Software for Certain C4.4 Machine Engines {7610, 7620}
PM820, PM822, and PM825 Cold Planer Access Ladder Operation - Right Handrail Extend and Retract
New Bus Bar is Now Used on Certain 3516B HD Low-Voltage Generator Set Engines {4450, 445B} New Bus Bar is Now Used on Certain 3516B HD Low-Voltage Generator Set Engines {4450, 445B}
PM820, PM822, and PM825 Cold Planer Side Plate - Index Marks
The Fuel Injectors May Fail on Certain C7 and C9 Truck Engines {1251, 1254, 1290, 1713} The Fuel Injectors May Fail on Certain C7 and C9 Truck Engines {1251, 1254, 1290, 1713}
Procedure to Update Pump Electronic Tank Unit (PETU) Coolant Lines on Certain 797F and 793F Off-Highway Trucks {108H, 108J, 108K, 1091, 726A} Procedure to Update Pump Electronic Tank Unit (PETU) Coolant Lines on Certain 797F and 793F Off-Highway Trucks {108H, 108J, 108K, 1091, 726A}
Bolt Replacement Guidelines for Certain C175 20 cylinder Off-Highway Truck Engine Air System Support Components {0635, 1052} Bolt Replacement Guidelines for Certain C175 20 cylinder Off-Highway Truck Engine Air System Support Components {0635, 1052}
New Adapter Elbow Assembly for Self Cleaning Filter is now Used on Certain Off-Highway Trucks {5050} New Adapter Elbow Assembly for Self Cleaning Filter is now Used on Certain Off-Highway Trucks {5050}