Inlet and Exhaust Valves - Remove and Install
拆卸步骤
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件描述     | 数量     |
A     | 5S-1330     | 气门弹簧压缩器     | 1     |
开始:
- 拆xia 缸盖。 请参阅拆解和组装, "缸盖 - 拆卸"。
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 使用工具 (A) 压缩气门弹簧 (3) 。 拆卸挡圈锁 (5) 。
Show/hide table
图 1 | g01256834 |
Show/hide table
被弹簧力爆出的零件击中,会招致人员伤害。 确保穿上所有必要的保护装备。 遵照建议的程序,并使用所有建议的工具以释放弹簧力。 |
- 拆下工具 (A) 。 拆下弹簧挡圈 (4) 和气门弹簧 (3) 。
- 拆下气门密封 (1) 和气门 (2) 。
- 通过重复步骤 1 到 3 拆下其余进气门和排气门。
安装步骤
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件描述     | 数量     |
A     | 5S-1330     | 气门弹簧压缩器     | 1     |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 用清洁的机油润滑气门 (2) 。 将气门 (2) 安装到缸盖组件内。 将新气门密封圈 (1) 安装到气门导杆上。
Show/hide table
图 2 | g01256834 |
Show/hide table
当松开气门弹簧压缩器的时候,气门弹簧卡座会从气门中弹出。 保证气门弹簧卡座正确安装在气门推杆上。 为了防止造成人员伤害,在安装气门时,应远离气门弹簧卡座前方和气门弹簧。 |
- 将以下各项放到气门杆上:气门弹簧 (3) 和 弹簧挡圈 (4) 。
- 使用工具 (A) 压缩气门弹簧 (3) 。 安装挡圈锁 (5) 。
注: 安装时可以使用少量的润滑脂以保持挡圈锁 (5) 就位。
- 通过重复步骤 1 到 3 安装其余进气门和排气门。
End By: 安装缸盖。 请参阅 拆解和组装, "缸盖- 安装"。
Caterpillar Information System:
C13 and C15 On-Highway Engines Emissions Certification Film
C7 PETROLEUM Petroleum Engine Inlet and Exhaust Valve Springs - Remove and Install
Air Conditioning and Heating R134a for All Caterpillar Machines Identifying the Air Conditioning System
C280 Marine Propulsion Engines Intermittent Engine Shutdown
C280 Marine Auxiliary Engines Self-Diagnostics
G3508, G3512 and G3516 Engines Crankshaft - Remove
C7 On-Highway Engine Clean Gas Induction Cooler - Remove and Install
C7 PETROLEUM Petroleum Engine Exhaust Manifold - Remove and Install
C3.3 Industrial Engine Crankshaft Rear Seal - Install
C3.3 Industrial Engine Crankshaft Rear Seal - Remove
G3500 A3 Engines Engine Overload
G3500 A3 Engines Engine Overcrank
G3508, G3512 and G3516 Engines Crankshaft - Install
AccuGrade® GPS (CD700) Flashing Messages
C7 On-highway Engine Idler Pulley
AccuGrade® GPS (CD700) Radio Utility
C7 PETROLEUM Petroleum Engine Engine Oil Filter Base - Remove
G3500 A3 Engines Grounding Practices
G3500 A3 Engines General Information (Electronic Control System)
AccuGrade® GPS (CD700) Receiver Firmware Upgrade
AccuGrade® GPS (CD700) Display Firmware Upgrade
AccuGrade® GPS (CD700) Sensor Firmware Upgrade
C15 Industrial Engine Powertrain Data Link Circuit - Test
C7 PETROLEUM Petroleum Engine Engine Oil Filter Base - Disassemble