Premature Nose-Cone and King-Pin Wear May Occur on Certain 794, 796, and 798 Off-Highway Trucks {3260, 4314} Caterpillar


Premature Nose-Cone and King-Pin Wear May Occur on Certain 794, 796, and 798 Off-Highway Trucks {3260, 4314}

Usage:

794 AC HRT
Mining Truck
794 AC (S/N: HRT1-UP)
Off-Highway Truck/Tractor
794 AC (S/N: MT51-UP)
796 (S/N: HRZ1-UP)
798 (S/N: ST71-UP)

Reference: Service Magazine, M0103653, "Rear Axle Housing Bearing – Inspect and King-pin (Front) – Inspect Improves Performance on 794 Off-Highway Trucks"

Introduction

The problem that is identified below does not have a known permanent solution. Until a permanent solution is known, use the solution that is identified below.

Problem



Illustration 1g06419457
Location of nose-cone bearing


Illustration 2g06419458
Location of left-hand king-pin

Premature nose-cone and king-pin wear may occur on the machines listed above.

Solution

------ WARNING! ------

Do not operate or work on this product unless you have read and understood the instruction and warnings in the relevant Operation and Maintenance Manuals and relevant service literature. Failure to follow the instructions or heed the warnings could result in injury or death. Proper care is your responsibility.


Caterpillar is aware of this problem and recommends the following interim corrective action.

Nose-cone bearing and king-pin measurements must be taken at machine commissioning for new machine and anytime the nose-cone bearing and king-pin are replaced.

Inspect nose-cone bearing and king-pin wear every 2,000 hours during bearing and pin life.

Provide the following information to your dealer Technical Communicator (TC): TIB Media Number M0105790, machine serial number, and part hours at failure. Request the Dealer TC to submit the information through Continuous Process Improvement (CPI) feedback within the Service Information Management System (SIMSi).

Note: Refer to Service Magazine, M0103653, "Rear Axle Housing Bearing – Inspect and King-pin (Front) – Inspect Improves Performance on 794 Off-Highway Trucks".

Caterpillar Information System:

Diesel Exhaust Fluid (DEF) Pump on Certain C4.4 Engines {108U, 1439} Diesel Exhaust Fluid (DEF) Pump on Certain C4.4 Engines {108U, 1439}
EMCP 4.4 1G1U (Single Generator, Single Utility) Checklist {7002} EMCP 4.4 1G1U (Single Generator, Single Utility) Checklist {7002}
340 Excavator Mirror
Installation Procedure for 2nd Auxiliary Lines Kit on Certain Mini Hydraulic Excavators {5057} Installation Procedure for 2nd Auxiliary Lines Kit on Certain Mini Hydraulic Excavators {5057}
Inspection of the Rear of the Engine on Certain C4.4 Machines {1201} Inspection of the Rear of the Engine on Certain C4.4 Machines {1201}
Certain Cat® Product Link A6 Platform Network Managers May Stop Reporting and Loses Communication {7606} Certain Cat® Product Link A6 Platform Network Managers May Stop Reporting and Loses Communication {7606}
The 521-5433 Fuel Pump Gp May Fail on Certain 3500 Industrial Engines {1256} The 521-5433 Fuel Pump Gp May Fail on Certain 3500 Industrial Engines {1256}
Improved Assembly Process for the Pin in the Windshield Group Is Now Available for Certain Excavators {7310} Improved Assembly Process for the Pin in the Windshield Group Is Now Available for Certain Excavators {7310}
Improved Attachment Valve (F2) Is Now Used on Certain 320, 320 GC and 323 Excavators {5051} Improved Attachment Valve (F2) Is Now Used on Certain 320, 320 GC and 323 Excavators {5051}
New Resistance Temperature Device (RTD) Module Software Is Now Used for Certain Engines {1920} New Resistance Temperature Device (RTD) Module Software Is Now Used for Certain Engines {1920}
Inspect the 144-0367 Hose Clamps Between the Sea Water Pump Outlet and Aftercooler Inlet on Certain C18 Marine Engines {1063, 3319} Inspect the 144-0367 Hose Clamps Between the Sea Water Pump Outlet and Aftercooler Inlet on Certain C18 Marine Engines {1063, 3319}
New Engine Software is Now Used For Certain G3520 Generator Sets {1920} New Engine Software is Now Used For Certain G3520 Generator Sets {1920}
An Improved Cooling System Venting Procedure is Now Available in the Operation and Maintenance Manual for Certain C175 Off-Highway Truck Engines {0374, 1350} An Improved Cooling System Venting Procedure is Now Available in the Operation and Maintenance Manual for Certain C175 Off-Highway Truck Engines {0374, 1350}
New Hard Washers are Used for the Mounting Hardware on the Oil Scavenge Pump for Certain C175 Off-Highway Truck Engines {1312} New Hard Washers are Used for the Mounting Hardware on the Oil Scavenge Pump for Certain C175 Off-Highway Truck Engines {1312}
An Improved Fuel Injector is Now Used on Certain C9.3 Machine Engines {1251, 1254, 1290, 1713} An Improved Fuel Injector is Now Used on Certain C9.3 Machine Engines {1251, 1254, 1290, 1713}
New Engine Software Is Now Used for Certain C175 Locomotive Engines {1920} New Engine Software Is Now Used for Certain C175 Locomotive Engines {1920}
Identifying Oil Leaks on Certain 3500 Mining Machine Engines {1151, 1348} Identifying Oil Leaks on Certain 3500 Mining Machine Engines {1151, 1348}
New Tooling and Installation Process for Crankshaft Seal on C27 and C32 Engines {0701, 1160, 1161} New Tooling and Installation Process for Crankshaft Seal on C27 and C32 Engines {0701, 1160, 1161}
Improved Auxiliary Sea Water Pump Group is Now Used on Certain C12 Marine Engines {1371} Improved Auxiliary Sea Water Pump Group is Now Used on Certain C12 Marine Engines {1371}
New Shipping Procedure Is Now Used for Stick Cylinder Pinned in Shipping Position on Certain 308 and 309 Mini Hydraulic Excavators {0355} New Shipping Procedure Is Now Used for Stick Cylinder Pinned in Shipping Position on Certain 308 and 309 Mini Hydraulic Excavators {0355}
New Solenoid Assembly is Now Used on Fuel Injectors for Certain C9.3 Industrial Engines {1251, 1290} New Solenoid Assembly is Now Used on Fuel Injectors for Certain C9.3 Industrial Engines {1251, 1290}
New Engine Software for Certain C7.1 Engines {1920} New Engine Software for Certain C7.1 Engines {1920}
New Engine Harness Assembly is Now Available For Certain Excavators and Mobile Hydraulic Power Units {1408} New Engine Harness Assembly is Now Available For Certain Excavators and Mobile Hydraulic Power Units {1408}
The Fuel Vent Tube May Crack on Certain C175–16 Marine Engine {1274} The Fuel Vent Tube May Crack on Certain C175–16 Marine Engine {1274}
Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.