Coolant Temperature Regulator - Replace
为这些系统更换水温调节器。
- 水套水
- 机油冷却器
- 后冷器
在水温调节器损坏前就应更换水温调节器。 此程序是推荐的预防性保养实践。 更换水温调节器可减少计划外停机的概率。
水温调节器在部分开启位置失效时,会引起发动机过热或过冷。
水温调节器在完全关闭位置失效时,会引起发动机严重过热。 发动机严重过热会引起气缸盖开裂或活塞卡缸故障。
水温调节器在开启位置失效时,会引起发动机在部分负荷时工作温度过低。 发动机部分负荷时工作温度过低会造成气缸内过分积碳, 从而加速活塞环和缸套的磨损。 此外,低温也会使湿气凝结到机油中。 此湿气可能会形成有害的酸。
Show/hide table
注意 |
---|
不能定期有计划地更换水温调节器会引起发动机严重损坏。 切勿在没有安装温度调节器的情况下运行发动机。 如果水温调节器安装不正确,发动机可能过热,造成气缸盖损坏。 确保新的水温调节器安装在原来的位置。 |
注: 如果只更换水温调节器,排放冷却系统中的冷却液至液位低于水温调节器壳即可。
Caterpillar Information System:
G3600 A4 Engines Coolant Sample (Level 2) - Obtain
G3600 A4 Engines Coolant Sample (Level 1) - Obtain
G3600 A4 Engines Coolant Level Switch - Inspect/Test
2013/09/25 An Improved Fuel Transfer Pump Assembly Is Now Available for Certain C9.3 ACERT Engines {1251, 1256, 1290}
G3600 A4 Engines Coolant Level - Check
G3600 A4 Engines Coolant (NGEC) - Change
C15 and C18 Engines for Caterpillar Built Machines Programmable Parameters
C13 and C15 Generator Sets Generator Start-up Checklist
2013/11/04 New Boost Pressure Sensor Location Is Used for Certain 3512 Petroleum Engines {1408, 1439, 1917}
C13 and C15 Generator Sets Battery Disconnect Switch - If Equipped
CX31 and CX31 HT On-Highway Transmissions Reference Material
C15 and C18 Engines for Caterpillar Built Machines ECM - Replace
Quick Start Wiring Guide for Dynamic Gas Blending Well Service Engines{1000, 1408, 1900, 1901, 7610, 7620} Quick Start Wiring Guide for Dynamic Gas Blending Well Service Engines{1000, 1408, 1900, 1901, 7610, 7620}
G3600 A4 Engines Crankcase Blowby - Test/Record
G3600 A4 Engines Cylinder Pressure - Test/Record
G3600 A4 Engines Engine Air Cleaner Element (Single Element) - Inspect/Clean/Replace
G3600 A4 Engines Engine Air Precleaner - Check/Clean
G3600 A4 Engines Engine Mounts - Inspect
G3600 A4 Engines Engine Valve Lash - Check
G3600 A4 Engines Fuel Filter Differential Pressure - Check
G3600 A4 Engines Inlet Air System - Check
G3600 A4 Engines Inlet Gas Manifold and Piping - Check
C15 and C18 Engines for Caterpillar Built Machines Electrical Connectors
C15 and C18 Engines for Caterpillar Built Machines Alternator Problem