Fan Drive - Assemble
组装步骤
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件说明     | 数量     |
A     | 1P-0510     | 起子总成     | 1     |
B     | 8T-1807     | 轴承润滑     | 1     |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 使用适当的压具将轴安装到支架中。
Show/hide table
图 1 | g01157241 |
- 将销 (2) 安装到轴组件 (1) 中。
Show/hide table
图 2 | g01157178 |
- 使用工具 (A) 将轴承外圈安装到风扇驱动毂 (6) 中。
- 将工具 (B) 涂敷在风扇驱动毂 (6) 的内部。
- 将轴承内圈 (5) 和 (8) 组装到工具 (B) 上。
- 将轴承内圈 (5) 和隔套 (4) 安装到风扇驱动毂 (6) 内。
- 使用工具 (A) 将油封 (3) 安装到风扇驱动毂 (6) 中。
- 将轴组件 (1) 安装到驱动毂 (6) 中。
- 安装隔套 (7) 和轴承内圈 (8) 。
- 安装螺栓 (9) 和垫圈。 拧紧螺栓 (9) ,使其扭矩达到 115 ± 5 N·m (85 ± 4 lb ft)。
- 安装盖 (10) 。
End By: 安装风扇驱动装置。 请参阅 拆解和组装, "风扇驱动装置 - 安装"。
Caterpillar Information System:
3606 and 3608 Engines Cylinder Block
G3400 Engines (EIS) Control Module Self Test
C9 Engines for Caterpillar Built Machines Fan Drive - Disassemble
C9 Engines for Caterpillar Built Machines Fan Drive - Install
3500 Generator Sets Fuel System Primary Filter/Water Separator - Drain
C280 Marine and Petroleum Engines Crankcase Breather
G3400 Engines (EIS) Diagnostic Codes
2006/01/16 40 Power Microscope is Available for Inspecting Bearing Journals on Crankshafts {0777, 1202}
C13 and C15 On-highway Engines Engine Misfires, Runs Rough or Is Unstable
Procedure for Filtering 9U-5000 Hydraulic Test Bench Hydraulic Oil {0680, 0738, 0768, 0784, 5050, 5056} Procedure for Filtering 9U-5000 Hydraulic Test Bench Hydraulic Oil {0680, 0738, 0768, 0784, 5050, 5056}
3500 Generator Sets Starting the Engine
C13 and C15 On-highway Engines Engine Cranks but Does Not Start
3618 Engine Refill Capacities and Recommendations
C27 and C32 Engines Air Inlet and Exhaust System - Inspect
G3400 Engines (EIS) Electrical Power Supply
C4.4 Marine Generator Set Engines Fuel Priming Pump and Fuel Filter Base - Remove and Install
TH48-E80 Petroleum Transmission Lubricant Viscosities
C27 and C32 Engines Cooling System - Check - Overheating
3618 Engine Fuel System Primary Filter (Water Separator) Element - Replace
C27 and C32 Engines Cooling System - Test
TH48-E80 Petroleum Transmission Capacities (Refill)
C27 and C32 Industrial and Petroleum Engines Water Pump - Test
G3400 Engines (EIS) Propane Switch
G3400 Engines (EIS) Shutdown Lamp