Hydraulic Cylinder (Steering) - Remove and Install
Start By:
- Release system pressure.
Show/hide table
 |
|
Personal injury can result from hydraulic oil pressure and hot oil. Hydraulic oil pressure can remain in the hydraulic system after the engine has been stopped. Serious injury can be caused if this pressure is not released before any service is done on the hydraulic system. Make sure all of the work tools have been lowered to the ground, and the oil is cool before removing any components or lines. Remove the oil filler cap only when the engine is stopped, and the filler cap is cool enough to touch with your bare hand. |
- Disconnect hose assemblies (2). Remove pin (3). Remove pin (4) and steering cylinder (1).
Show/hide table
| |
| Illustration 1 | g03203064 |
- Install steering cylinder (1) in reverse order of removal.
Caterpillar Information System:
2012/09/10 New Communication Software Group For VIMS 3G Software Is Now Used On Certain Off-Highway Trucks {7620}
770G and 772G Off-Highway Truck/Tractors Wiring Harness (Open Circuit) - Test
770G and 772G Off-Highway Truck/Tractors Wiring Harness (Short Circuit) - Test
CW14 Pneumatic CompactorMachine Systems Axle (Front) - Remove and Install
CB34B, CB34B XW, CB36B and CC34B Utility Compactors Additive Spray System - Drain
C175-16 Engine for Off-Highway Trucks Exhaust Fitting
MH3049 Material Handler Hydraulic System Hydraulic Filter (Pilot)
CB34B, CB34B XW, CB36B and CC34B Utility Compactors Additive Spray System - If Equipped
521B and 522B Track Feller Bunchers Machine Systems Boom Cylinder - Remove and Install
2012/10/23 The New Aftercooler Core Assembly (ATAAC) Is Now Used on Certain 24M Motor Graders {1063, 1064, 1079}
Procedure to Update Front Light Wiring Harness Assembly On Certain Motor Graders{4334} Procedure to Update Front Light Wiring Harness Assembly On Certain Motor Graders{4334}
12M Motor Grader TA2 Technical Inspection{7000} 12M Motor Grader TA2 Technical Inspection{7000}
770G and 772G Off-Highway Truck/Tractors General Information
521B and 522B Track Feller Bunchers Machine Systems Boom - Remove and Install
770G and 772G Off-Highway Truck/Tractors Service Tools
770G and 772G Off-Highway Truck/Tractors Connector Locations
2012/09/06 Improved Piston Kit Update the Steering Accumulator Group on Certain Off-Highway Trucks {4331, 4331}
C175-16 Engine for Off-Highway Trucks Exhaust Lines
CW14 Pneumatic CompactorMachine Systems Wheel and Tire - Remove and Install
770G and 772G Off-Highway Truck/Tractors Diagnostic Capabilities
521B and 522B Track Feller Bunchers Machine Systems Boom Bearings and Seals - Remove and Install
770G and 772G Off-Highway Truck/Tractors Machine Preparation for Troubleshooting
R3000H Load Haul Dump Braking System Sequence Valve (Brake Release)
R3000H Load Haul Dump Braking System Brake Release Cylinder