Fuel Temperature Is High
采用此步骤对燃油温度高进行故障排除。 在以下任一事件码为现行状态时使用本步骤。 有关事件代码和这些代码的默认触发点的信息,请参阅 故障诊断与排除, "事件代码列表"。 必须进入 Caterpillar 电子技师(ET)的监控系统才能查看这些代码的当前触发点。
Show/hide table
事件代码 | ||
---|---|---|
代码和描述 | 产生此代码的状况 | 系统响应 |
E056(1) 燃油温度高警告 | 燃油温度高于触发点规定的延迟时间。 | 记录该代码。 |
- 燃油压力调节阀
- 燃油油位
- 燃油管
- 发动机过热
Show/hide table
故障诊断与排除测试步骤 | 数值 | 结果 |
1. 燃油压力调节阀 A. 燃油压力调节阀工作不正常可能会导致高燃油温度。 B. 如果怀疑有故障,检查回油压力调节阀。 |
燃油压力调节阀 |
结果:燃油压力调节阀中未发现碎屑。 转至测试步骤 2。 结果:燃油压力调节阀中发现碎屑。 如果存在碎屑,找出污染物的来源。 如果回油压力调节阀磨损或损坏,更换该阀。 |
2. 燃油油位 A. 确保燃油箱含有足够的燃油。 燃油箱油位下降时,燃油温度以便会升高。 |
燃油油位 |
结果:燃油油位正常。 转至测试步骤 3。 结果:燃油油位不正常。 向燃油箱加油。 |
3. 燃油管 A. 回油管受阻可能会导致燃油温度非常高。 确保流到燃油箱的回油没有受阻。 |
燃油管 |
结果:燃油管未阻塞。 继续测试步骤 4。 结果:燃油管阻塞。 修理阻塞或更换燃油管。 |
4. 发动机过热 A. 燃油通过缸盖中的油道供应至喷油器。 环境空气温度异常高可能会导致燃油温度达到触发水平。 发动机过热可能会导致燃油温度达到触发水平。 |
发动机 |
结果:发动机没有过热。 止动块 结果:发动机过热。 对发动机过热的原因进行故障排除。 |
Caterpillar Information System:
C4.4 Industrial Engine Severe Service Application
3176C and 3196 Marine Engines Transmission Operation
3176C and 3196 Marine Engines Configuration Parameters - Customer Specified Parameters
C32 Marine Engine Fuel Pressure Is Low
3176C and 3196 Marine Engines Product Lifting
3176C and 3196 Marine Engines Plate Locations and Film Locations
C32 Marine Engine Fuel Pressure Is High
3500B and 3500C Marine Engines Turbocharger
2013/02/06 A New Coolant Elbow Is Used on Certain 3500 Engines {1380, 7553}
3500B and 3500C Marine Engines Turbocharger
C175-16 Generator Set Engine Generator Coupling
C175-16 IMO III Offshore Engine Thermocouple
3176C and 3196 Marine Engines Fluid Recommendations
3176C and 3196 Marine Engines Belts - Inspect/Adjust/Replace
3176C and 3196 Marine Engines Engine Air Cleaner Element (Single Element) - Inspect/Clean/Replace - Air Cleaner Element and Vacuum Regulator Filters
C32 Marine Engine Inlet Air Temperature Is High
3512B SR4B Generator Sets Model View Illustrations
3176C and 3196 Marine Engines Engine Speed/Timing Sensor - Clean/Inspect
C32 Marine Engine Oil Contains Coolant
C32 Marine Engine Oil Pressure Is Low
C32 Marine Engine Oil Temperature Is High
C32 Marine Engines Coolant Level - Test
C1.5 and C2.2 Industrial Engines Coolant (DEAC) - Change
C1.5 and C2.2 Industrial Engines Coolant (ELC) - Change