V-Belt - Test
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件描述     | 数量     |
A     | 144-0235     | 传动带张力表     | 1     |
Show/hide table
皮带张紧度表     | |||||||||
---|---|---|---|---|---|---|---|---|---|
皮带尺寸     | 皮带宽度     | 仪表读数     | |||||||
初始皮带张力 (1) | 旧皮带张力 (2)     | ||||||||
1/2     | 13.89 mm (0.547 in)     |
535 N (120 lb)     |
355 N (80 lb)     |
||||||
测量离发动机最远的那根皮带的张紧度。     |
Show/hide table
( 1 ) | 初始皮带张力是指新皮带。 |
( 2 ) | 旧皮带张力是指已在额定转速下工作不低于 30 分钟的皮带。 |
将工具 (A) 安装在传动带最大自由长度的中心位置,并检查两条传动带的张力。 检查并调整最紧传动带的张力。 要调整传动带张力,请参阅拆解和组装, "交流发电机 - 安装"。
多 V 形传动带
Show/hide table
注意 |
---|
确保在进行任何维护和修理工作之前关闭发动机。 |
为使发动机性能最大化,检查多 V 形传动带 (1) 是否磨损和开裂。 如果多 V 形传动带磨损或损坏,则更换传动带。
- 如果多 V 形传动带 (1) 每 25.4000 mm (1 inch) 的长度上有超过四条裂纹,则必须更换传动带。
- 检查多 V 形传动带有无裂纹、裂口、磨光、油脂和裂缝。
Show/hide table
图 1 | g01335967 |
典型实例 |
要更换多 V 形传动带,请参阅拆解和组装, "交流发电机传动带 - 拆卸和安装"。
如有必要,更换传动带张紧装置。 请参阅拆解和组装, "交流发电机传动带 - 拆卸和安装"。
Caterpillar Information System:
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys General Information (Input/Output Cabinet)
UPS 120, UPS 150, UPS 250, UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies Modem - Configure
C4.4 Industrial Engine Crankshaft Pulley - Check
C4.4 Industrial Engine Alternator - Test
2006/05/22 Revised Product Support Update {0374}
TA22-4WD Agricultural Transmission Capacities (Refill)
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys Circuit Breaker (Maintenance Bypass Cabinet)
C9 Engine for Caterpillar Built Machines Camshaft - Install
UPS 120, UPS 150, UPS 250, UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies Remote Notification - Setup
UPS 120, UPS 150, UPS 250, UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies Emergency Power Off - Reset
C9 Engine for Caterpillar Built Machines Camshaft - Remove
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys Cable Landing (Maintenance Bypass Cabinet)
797B Off-Highway Truck Steering System Steering Accumulator - Test and Charge
UPS 120, UPS 150, UPS 250, UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies Log File - Retrieve
CX35 On-Highway Transmission Lubricant Viscosities
UPS 120, UPS 150, UPS 250, UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies Firmware - Update
UPS 120, UPS 150, UPS 250, UPS 300, UPS 301, UPS 500, UPS 600, UPS 750 and UPS 900 Uninterruptible Power Supplies Personal Computer to UPS Connection
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys Internal Component Preremoval Steps (Input/Output Cabinet)
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys System Fuse (Input/Output Cabinet)
797F Off-Highway Truck Steering System Steering Accumulator
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys Reset Pushbutton
C11 and C13 Petroleum Engines Fuel System Secondary Filter - Replace
TH48-E70 Petroleum Transmission Specifications
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys Breaker Bell Alarm Supervisor Board