Universal Joint for the Hydraulic Hand Control Group May Fail on Certain 424B Backhoe Loaders {5063}
- Backhoe Loader
- 424B (S/N: JRN1-UP)
- 424B HD (S/N: JRY1-UP)
Introduction
The problem that is identified below does not have a known permanent solution. Until a permanent solution is known, use the solution that is identified below.
Problem
Universal joint for the hydraulic hand control group may fail on the machines listed above. Due the universal joint being excessively tight, the stick lever movement is hard.
Show/hide table
Illustration 1 | g06189483 |
Universal joint failure area |
Solution
In the event of failure, replace the 444-5319 Universal Joint with the same part.
Caterpillar Information System:
Cylinder Assembly for the Service Brake Control Group May Fail on Certain 424B and 424B HD Backhoe Loaders {4269} Cylinder Assembly for the Service Brake Control Group May Fail on Certain 424B and 424B HD Backhoe Loaders {4269}
SE50 VT Asphalt Screed Hydraulic Cylinder (Extender)
AP555F Asphalt Paver Machine Systems Hopper
AP655F and AP655F L Asphalt Paver Machine Systems Auger Extension
AP655F and AP655F L Asphalt Paver Machine Systems Auger Extension
AP655F and AP655F L Asphalt Paver Machine Systems Position Sensor (Sonic)
AP555F Asphalt Paver Machine Systems Tow Arm
AP655F and AP655F L Asphalt Paver Machine Systems Auger Extension - 750 mm (29.5 inch)
R1700 Load Haul Dump Engine Overspeed Control
3516E Engines for Caterpillar Built Machines Rocker Shaft and Push Rods - Install
725C, 725C2, 730C and 730C2 Articulated Truck Systems Suspension Height (Front) - Check and Adjust
C175 Tier 4 Final Engines for Off-Highway Trucks Cylinder Block, Liners and Heads
Boot for the Hydraulic Hand Control Group May Fail on Certain 424B Backhoe Loaders {5063} Boot for the Hydraulic Hand Control Group May Fail on Certain 424B Backhoe Loaders {5063}
Meter Assembly for the Console Wiring Group May Malfunction on Certain 424B Backhoe Loaders {1408} Meter Assembly for the Console Wiring Group May Malfunction on Certain 424B Backhoe Loaders {1408}
Start Switch Assembly in the Console Wiring Group May Malfunction on Certain 424B Backhoe Loaders {1408} Start Switch Assembly in the Console Wiring Group May Malfunction on Certain 424B Backhoe Loaders {1408}
Solenoid Valve in the Transmission Hydraulic Control Group May Malfunction on Certain 424B Backhoe Loaders {3073, 3167} Solenoid Valve in the Transmission Hydraulic Control Group May Malfunction on Certain 424B Backhoe Loaders {3073, 3167}
Bushing Failures May Occur in the Boom on Certain 424B Backhoe Loaders {6501} Bushing Failures May Occur in the Boom on Certain 424B Backhoe Loaders {6501}
Hose Assembly May Leak Oil / Lube in the Hydraulic Oil Lines Group on Certain 424B Backhoe Loaders {5057} Hose Assembly May Leak Oil / Lube in the Hydraulic Oil Lines Group on Certain 424B Backhoe Loaders {5057}
745 & 740 GC Articulated Truck Brake Line Pressure for Front Axle - Test
745 & 740 GC Articulated Truck Brake Line Pressure for Center and Rear Axle - Test
740 Ejector Articulated Truck Frame and Body - Lubricate
426F2 Backhoe Loader Power Train Axle Housing and Flange - Disassemble
24H Motor Grader Hydraulic and Steering System Hydraulic and Steering System
24H Motor Grader Hydraulic and Steering System Accumulator (Steering) - Test and Charge