Incorrect Dip Stick (Oil Level Gauge) May Be Installed
Usage:
ENGINES3500 AND 3500B ENGINES (SEE INCLUDED CHART) EQUIPPED WITH SHALLOW OIL PANS
Problem:
An oil level gauge intended for use with deep sump oil pans may have been installed in some engines equipped with shallow oil pans.
Solution:
Check the engines listed in the chart. If you have one of these engines and it is equipped with a shallow oil sump (500 hour pan), check the oil level gauge. If a 7C-9786 Oil Level Gauge is found, replace it with the correct 4P-3784 Oil Level Gauge.
COPYRIGHT 1997 CATERPILLAR ALL RIGHTS RESERVED
Caterpillar Information System:
Repeated "No Mag Interface"Shutdowns Repeated "No Mag Interface"Shutdowns
Excessive Oil Leakage From Hydraulically Actuated Electronic Unit Injectors (Heui) Excessive Oil Leakage From Hydraulically Actuated Electronic Unit Injectors (Heui)
New Exhaust Valve Lash Setting Dimensions New Exhaust Valve Lash Setting Dimensions
Fuel Priming Pump Leak Fuel Priming Pump Leak
Some 9X-7803 Alternators Were Mislabeled As 8C-6163 Some 9X-7803 Alternators Were Mislabeled As 8C-6163
Remanufacturing Water Pumps For The 3300 Family Of Engines Remanufacturing Water Pumps For The 3300 Family Of Engines
Fuel In Engine Oil Fuel In Engine Oil
Idler Stub Shaft Mounting Bolts; Idler Gear Sleeve Bearings Idler Stub Shaft Mounting Bolts; Idler Gear Sleeve Bearings
Remanufactured Water Pumps For 3204 And 3208 Engines Remanufactured Water Pumps For 3204 And 3208 Engines
Additional Holes In Cylinder Head Gasket Additional Holes In Cylinder Head Gasket
Cooling System Filling Procedure Cooling System Filling Procedure
Engines Won't Shut-Off Engines Won't Shut-Off
Excessive Wear And Breakage Of 124-6639 Thrust Plate In 125-3427 Pump Drive Group (HEUI Hydraulic Pump Drive) Excessive Wear And Breakage Of 124-6639 Thrust Plate In 125-3427 Pump Drive Group (HEUI Hydraulic Pump Drive)
Unit Injector Hold Down Bolts Unit Injector Hold Down Bolts
Possible Fuel Leak From The Weep Hole In Stanadyne Model DB4 Fuel Injection Pumps On 3054 and 3056 Engines Possible Fuel Leak From The Weep Hole In Stanadyne Model DB4 Fuel Injection Pumps On 3054 and 3056 Engines
Unapproved Refrigerant Use In Caterpillar HVAC Systems May Adversely Effect Air Conditioner Performance Unapproved Refrigerant Use In Caterpillar HVAC Systems May Adversely Effect Air Conditioner Performance
Check Cylinder Block After Exhaust Manifold Failures Check Cylinder Block After Exhaust Manifold Failures
3300 Engine Timing Measurement For Reduced Emissions And Improved Engine Performance/Life 3300 Engine Timing Measurement For Reduced Emissions And Improved Engine Performance/Life
Electronic Monitoring System II (EMS II) Communication Problems Electronic Monitoring System II (EMS II) Communication Problems
Some Remanufactured Electric Starter Groups May Have An Incorrect Nose Housing Some Remanufactured Electric Starter Groups May Have An Incorrect Nose Housing
Repeated "No Mag Interface" Shutdowns Repeated "No Mag Interface" Shutdowns
G3600 Engine Spark Plug Service Life G3600 Engine Spark Plug Service Life
Exhaust Bypass Valve (Wastegate) Rod End Damage Exhaust Bypass Valve (Wastegate) Rod End Damage
Incorrect Installation Of 146-6692 Primary Fuel Filter/Water Separator Incorrect Installation Of 146-6692 Primary Fuel Filter/Water Separator