Valve Lifter - Install
Show/hide table
Required Tools | |||
Tool | Part Number | Part Description | Qty |
A | 3E-3879 | Eyebolt | 1 |
- Install integral seal (5).
Show/hide table
Illustration 2 g02036314 Show/hide tableIllustration 3 g02036313 - Attach Tooling (A) and a suitable lifting device onto valve lifter (3). Position valve lifter (3) onto the engine. Install bolts (4). Tighten bolts (4) to a torque of
55 ± 10 N·m (41 ± 7 lb ft) . - Position manifold shield (1) and install the washers and bolts (2).
- Repeat Steps 1 and 3 for the manifold shield and the remaining valve lifters.
Show/hide table
NOTICE |
---|
Keep all parts clean from contaminants. Contaminants may cause rapid wear and shortened component life. |
Show/hide table
Illustration 1 | g02036315 |
End By:
- Install the exhaust manifolds.
- Install the rocker shaft and pushrods.
Caterpillar Information System:
C175 Tier 4 Final Engines for Off-Highway Trucks DEF Pressure Does Not Respond
M0074040: 509-5085 Lifting Tool Assembly {0374, 0599, 0629, 0632, 3023, 3159, 3160, 5363, 7000} M0074040: 509-5085 Lifting Tool Assembly {0374, 0599, 0629, 0632, 3023, 3159, 3160, 5363, 7000}
C12.9 Marine Engines Crankshaft Front Seal - Remove and Install
New Basic Engine Components Are Used in C175-16 Engines {1202, 1205} New Basic Engine Components Are Used in C175-16 Engines {1202, 1205}
A New Drive Bearing Is Now Used on Certain 3406E, C11, C13, C15, C16, and C18 Machine Engines {1207} A New Drive Bearing Is Now Used on Certain 3406E, C11, C13, C15, C16, and C18 Machine Engines {1207}
New CAT Inspect Form Available for EMCP Troubleshooting and Inspection {0374, 4490, 7451, 7620} New CAT Inspect Form Available for EMCP Troubleshooting and Inspection {0374, 4490, 7451, 7620}
Identifying Oil Pumps on Certain C27, C32, and 3412 Engines {1304} Identifying Oil Pumps on Certain C27, C32, and 3412 Engines {1304}
HPU300 Hydraulic Power Pack Daily Inspection
HPU300 Hydraulic Power Pack Storage
C12.9 Marine Engines Camshaft Bearings - Remove and Install
SPF343 and SPF343C Trailer Mounted Pumpers Monitoring System
PM820, PM822, and PM825 Cold Planer Machine Systems Flashing (Conveyor) - Remove and Install
Front Suspension Failures May Occur on Certain 777D/777F/777G Off-Highway Trucks {7200, 7201, 7551} Front Suspension Failures May Occur on Certain 777D/777F/777G Off-Highway Trucks {7200, 7201, 7551}
C175-16 and C175-20 Locomotive Engines Air Inlet Manifold - Remove and Install
C175-16 and C175-20 Locomotive Engines Fuel Pump (High Pressure) - Remove and Install
349F and 352F Excavators Machine System Specifications Swing Drive - Left Swing Drive and Right Swing Drive
ECPC Valves May Fail on Cat Transmission Systems {3073, 3139, 3167} ECPC Valves May Fail on Cat Transmission Systems {3073, 3139, 3167}
C4.4 and C6.6 Engines Diagnostic Trouble Codes
HPU300 Hydraulic Power Pack Hydraulic Oil Filter - Replace
A New Cylinder Liner Assembly And Piston Is Now Used For Certain 3516 Locomotive Engines {1201, 1216} A New Cylinder Liner Assembly And Piston Is Now Used For Certain 3516 Locomotive Engines {1201, 1216}
Failure Analysis Report - AFA Good Report {0374, 1000} Failure Analysis Report - AFA Good Report {0374, 1000}
C4.4 and C6.6 Engines General Information
C4.4 and C6.6 Engines Welding Precaution
C4.4 and C6.6 Engines Component Location