Start Relay (Starter Two) Test Description
Show/hide table
| |
| 图 1 | g01285410 |
该测试测量起动继电器两端的电压降。 电压降通过测试点 (9) 和测试点 (14) 测量。 测试点 (9) 为正极连接，而测试点 (14) 为负极连接。
电压降将导致起动电磁阀的指示灯点亮。 电压降必须大于 0.45 ± 0.15 伏。 灯点亮是了为说明有缺陷。 所有测试步骤中的故障均会指示。 "测试步骤 B，起动"是最常用的测试，用于识别故障。
该故障可能的原因如下：
- 电磁阀常开触点
- 带过高电压降的电磁阀常闭触点
Caterpillar Information System:
3176C Engines for Caterpillar Built Machines CID 0296 FMI 09 Unable to communicate with Transmission ECM
Starting and Charging Systems Starter Solenoid (Starter One) Test Description
Field Installation for the 281-7219 Cab Window Kit {7310} Field Installation for the 281-7219 Cab Window Kit {7310}
AccuGrade® GPS General Information
3176C Engines for Caterpillar Built Machines Digital Sensor Supply Circuit - Test
Filtration Procedure for Off-Highway Truck (769-777) Rear Axle Oil {0680, 0768, 3260, 4050} Filtration Procedure for Off-Highway Truck (769-777) Rear Axle Oil {0680, 0768, 3260, 4050}
793D Off-Highway Truck/Tractor Front Suspension (Cylinder) - Assemble
793D Off-Highway Truck/Tractor Front Suspension (Cylinder) - Disassemble
12M, 140M and 160M Motor Graders Hydraulic and Steering System Hydraulic Tank Mounting
2006/09/04 New Differentials Are Used {3256, 3278}
R1700G Load Haul Dump Hydraulic System Pilot Hydraulic System
R1700G Load Haul Dump Payload Control System (PCS) - If Equipped
Starting and Charging Systems Starter Solenoid Power Circuit (Starter Two) Test Description
3176C Engines for Caterpillar Built Machines CID 1599 FMI 05 Engine Fan Pull Solenoid open circuit
3176C Engines for Caterpillar Built Machines CID 1599 FMI 06 Engine Fan Pull Solenoid short to ground
3176C Engines for Caterpillar Built Machines CID 1600 FMI 06 Engine Fan Push Solenoid short to ground
3176C Engines for Caterpillar Built Machines CID 1600 FMI 05 Engine Fan Push Solenoid open circuit
3176C Engines for Caterpillar Built Machines CID 0545 FMI 06 Ether Start Relay short to ground
14M and 16M Motor Graders Power Train Relief Valve (Cooler Bypass)
3176C Engines for Caterpillar Built Machines CID 0545 FMI 05 Ether Start Relay open/short to +batt
14M and 16M Motor Graders Power Train Modulating Valve (Transmission Hydraulic Control)
2006/07/10 Improved Grease Is Now Used in the Front Suspension Group {7200, 7201}
Improvements to the Engine Compartment on Landfill Compactors{1000, 7000} Improvements to the Engine Compartment on Landfill Compactors{1000, 7000}
14M and 16M Motor Graders Power Train Relief Valve - Transmission Gear Lube