Fan Drive - Disassemble
Removal Procedure
Start By:
- Remove the fan drive. Refer to Disassembly and Assembly, "Fan Drive - Remove".
- Thoroughly clean the outside of the fan and the fan drive prior to disassembly.
- Remove bolt (1) and plate (2) .
Show/hide table
Illustration 1 | g00894086 |
- Remove bearing (3) .
Show/hide table
Illustration 2 | g00894087 |
- Remove hub (4) from shaft assembly (5) .
Show/hide table
Illustration 3 | g00894088 |
- Remove spacer (6) .
Show/hide table
Illustration 4 | g00894090 |
- Remove spacer (8) and pin (7) from shaft assembly (5) .
Show/hide table
Illustration 5 | g00894091 |
- Remove lip type seal (9). Remove bearing (10) .
Show/hide table
Illustration 6 | g00894092 |
- Remove bearing race (11) .
Show/hide table
Illustration 7 | g00894093 |
Caterpillar Information System:
797B Off-Highway Truck Suspension Cylinder Pressure Sensor (Payload)
814F Wheel Dozer, 815F Soil Compactor and 816F Landfill CompactorEngine Supplement Fuel Filter (Secondary) and Fuel Filter Base - Remove and Install - Engine in Chassis
CP-533C, CP-563C, CS-533C, CS-563C, CS-573C and CS-583C Paving Compactors Propel System Axle
RM-250C, RR-250B and RM-350B Additive Spray System Setup Procedure
814F Wheel Dozer, 815F Soil Compactor and 816F Landfill CompactorEngine Supplement Electronic Unit Injector - Install
793C XQ Off-Highway Truck and 793C Off-Highway Truck Engine Supplement Fan Drive (Hydraulic) - Remove
797B Off-Highway Truck Engine Air Precleaner - Clean
814F Wheel Dozer, 815F Soil Compactor and 816F Landfill CompactorEngine Supplement Electronic Unit Injector - Remove
RM-250C Reclaimer Mixer and RM-350B and RR-250B Road Reclaimer/Soil Stabilizers Additive Spray System Relief Valve (Charge) - Test and Adjust
RM-250C Reclaimer Mixer and RM-350B and RR-250B Road Reclaimer/Soil Stabilizers Additive Spray System Piston Pump Flow - Test
2002/06/10 Installing a Stiffener Plate to the Lift Cylinder Tube Assemblies Increases Service Life {5057}
R1600G Load Haul Dump Steering System Solenoid Valve (Reversible Steering)
793C XQ Off-Highway Truck and 793C Off-Highway Truck Engine Supplement Fan Drive (Hydraulic) - Install
69D, 73D, 769C, 769D, 773B, 773D, 773E, 776B, 776C, 776D, 777B, 777C, 777D, 784B, 785, 785B, 789 and 793 Off-Highway Truck/Tractors and 771D, 775B, 775D and 775E Quarry Trucks Payload System Payload F02 - Suspension Cylinder (Right Front) Incorrect Charge
69D, 73D, 769C, 769D, 773B, 773D, 773E, 776B, 776C, 776D, 777B, 777C, 777D, 784B, 785, 785B, 789 and 793 Off-Highway Truck/Tractors and 771D, 775B, 775D and 775E Quarry Trucks Payload System Payload F03 - Suspension Cylinder (Left Rear) Incorrect Charge
CB-434C Vibratory Compactor Safety Messages
69D, 73D, 769C, 769D, 773B, 773D, 773E, 776B, 776C, 776D, 777B, 777C, 777D, 784B, 785, 785B, 789 and 793 Off-Highway Truck/Tractors and 771D, 775B, 775D and 775E Quarry Trucks Payload System Payload F04 - Suspension Cylinder (Right Rear) Incorrect Charge
814F Wheel Dozer, 815F Soil Compactor and 816F Landfill CompactorEngine Supplement Fan Drive - Assemble
PM-465 Cold Planer Hydraulic Tank Breather - Replace
PS-150B and PS-200B Paving Compactors Indicators and Gauges - Test
TH220B, TH330B, TH340B, TH350B, TH355B, TH360B, TH460B, TH560B and TH580B Telehandlers MID 039 - CID 1401 - FMI 05
PM-465 Cold Planer Legs (Struts) - Lubricate
2002/05/27 Use The 2P-4005 Engine Oil Filter Assembly If The Machine Engine Is Equipped With Spin-on Oil Filters {1308}
814F Wheel Dozer, 815F Soil Compactor and 816F Landfill CompactorEngine Supplement Fan - Remove and Install