Power Coupling System
Usage:
Enclosed Clutches And/Or Front Power Take-Off
Checking Clutch Adjustment
While engaging the clutch to pick up the load, check the clutch adjustment. The clutch should engage with a hard push and distinct snap. If engagement is "soft", adjust the clutch.
Adjusting Clutch
- 1. Stop the engine and remove the clutch inspection cover.
CLUTCH INSPECTION COVER
- 2. Turn the clutch until the lock pin, engaged in the locking ring, is visible.
- 3. Disengage the lock pin and rotate the locking ring clockwise until the lock pin engages the next notch.
PULLING LOCKING PIN
- 4. Test the clutch adjustment. If still too "soft", rotate the ring to the next notch. If the adjustment is too tight-turn the ring back one notch.
- 5. Install the cover.
Lubricating Flywheel Clutches And Front Power Take-Off Clutches
Lubricate the clutch bearings with grease, 1 or 2 strokes each fitting.
- 1. Lubricate the shift lever bearings; 1 fitting on each side of the clutch housing.
LUBRICATING SHIFT LEVER BEARINGS
- 2. Lubricate pilot bearing; 1 fitting at the end of shaft. If this fitting is not accessible, remove the plug located on the circumference of the shaft near the rear of the housing, and install a fitting.
PILOT, SHIFT COLLAR AND SHAFT BEARINGS
- 3. Lubricate shift-collar and shaft; 1 fitting at top-left of center.
- 4. Lubricate the shaft bearing; 1 fitting on top-rear of housing.
Caterpillar Information System:
G342C NATURAL GAS ENGINE Electrical System
G342C NATURAL GAS ENGINE Starting System
G342C NATURAL GAS ENGINE Cooling System
G342C NATURAL GAS ENGINE Fuel System
G342C NATURAL GAS ENGINE Engine Valves
G342C NATURAL GAS ENGINE Air Induction And Exhaust System
G342C NATURAL GAS ENGINE Engine Lubrication System
G342C NATURAL GAS ENGINE Valve Lash(Engine Cold)
G342C NATURAL GAS ENGINE Ignition Specifications
G342C NATURAL GAS ENGINE Refill Capacities (Approximate)
G342C NATURAL GAS ENGINE Recommended Viscosities At Various Starting Temperatures
G342C NATURAL GAS ENGINE Lubrication And Maintenance Chart
G342C NATURAL GAS ENGINE Miscellaneous Maintenance
D379B, D398B, D399 MARINE ENGINES Foreword
D379B, D398B, D399 MARINE ENGINES Marine Engine Emergency Repair Manual
D379B, D398B, D399 MARINE ENGINES General
D379B, D398B, D399 MARINE ENGINES Starting The Engine
D379B, D398B, D399 MARINE ENGINES Operating Engine And Marine Gear
D379B, D398B, D399 MARINE ENGINES Emergency Stopping Procedures
D379B, D398B, D399 MARINE ENGINES Storage
D379B, D398B, D399 MARINE ENGINES Woodward Governor Operation
D379B, D398B, D399 MARINE ENGINES Automatic Start-Stop
D379B, D398B, D399 MARINE ENGINES Emergency Alarms
D379B, D398B, D399 MARINE ENGINES Shutoff Devices