Engine Oil Pan - Remove and Install - G3408B
拆卸步骤
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件描述     | 数量     |
A     | -     | LOCTITE 5900 法兰密封胶     | 1     |
- 必要时,拆下导轨并将发动机放在适当的发动机台架上。
- 有关正确的排放和加注步骤,请参阅操作和保养手册, "发动机机油和滤清器 - 更换"。
- 拆下支架 (3) 。
Show/hide table
图 1 | g03331311 |
Show/hide table
图 2 | g03331382 |
- 使用适当的起吊设备或台架支承油底壳 (2) 。 油底壳 (2) 的重量大约为 170 kg (375 lb)。
- 拆下螺栓 (1) 后拆下油底壳 (2) 。
- 拆下滤网和抽吸管组件 (4) 。
Show/hide table
图 3 | g03331392 |
发动机倒置显示。 |
- 拆下管组件 (5) 和 O 形密封圈。 拆卸发动机机油泵 (6) 。
- 将密封垫 (7) 从油底壳上拆下。 丢弃密封垫 (7) 。
Show/hide table
图 4 | g03331447 |
安装步骤
- 按与拆卸相反的顺序安装油底壳 (2) 。
- 将工具 (A) 涂覆到位置 (X) 。 确保整个支座涂覆一层均匀的工具涂层,并填充所有缝隙。
Show/hide table图 5 g02694579
- 安装新密封垫 (7) 。 密封垫到位后,将工具 (A) 涂覆到位置 (X) 。
- 将清洁的发动机机油涂覆到管组件 (5) 的 O 形密封圈上。
Caterpillar Information System:
C32 Marine Engine Overhaul (Top End)
3500C Marine Engines Fuel Filter (Primary)
C32 Marine Engine Maintenance Recommendations
C32 Marine Engine Fuel System Secondary Filter - Replace
3500 Generator Sets with Dynamic Gas Blending Before Starting Engine
3500 Generator Sets with Dynamic Gas Blending Product Installation
C32 Auxiliary Engine Engine Oil and Filter - Change
PM3516 Power Modules Configuration Parameters
C6.6 Generator Sets Voltage Regulators
2012/12/11 A New Valve Body Is Used on Certain C32 Marine Engines {1306, 1308}
PM3516 Power Modules Fluid Recommendations
PM3516 Power Modules Refill Capacities
320D2 Excavator Equipment Lowering with Engine Stopped
2013/02/01 New Software Is Available for Certain C15 Generator Sets {1920}
3512B, 3512C, and 3516B Petroleum Engines and Petroleum Generator Set Engines with Dynamic Gas Blending System Overview
2013/01/08 Improved Shift Lever Handle, Hoist Lever Handle, Shift Indicator, And Hoist Indicator Is Now Available For Use On Certain Cat Products {3065, 5063}
C175-16 Locomotive Engine Sensor Signal (PWM) - Test
320D Excavator Oil Filter (Hydraulic Hammer) - Replace - If equipped
2012/12/20 Inspection of Injectors on Certain C27 and C32 Commercial Engines {1251, 1254, 1290, 1713}
CG137-08 and CG137-12 Engines Valve Cover - Remove and Install - G3408B
C175-16 Locomotive Engine Sensor Signal (Analog, Passive) - Test
Some Solenoids for Prelube Pumps and Starting Motors on Certain G3500B Engines Leak from the Exhaust Ports{1319, 1451} Some Solenoids for Prelube Pumps and Starting Motors on Certain G3500B Engines Leak from the Exhaust Ports{1319, 1451}
C1.5 and C2.2 Industrial Engines Fuel Related Components in Cold Weather
3500 Engines for Caterpillar Built Generator Sets Oil Level Regulator