Water Pump - Assemble
组装步骤
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件描述     | 数量     |
A.     | 1P-0510     | 冲头总成     | 1     |
B     | 5P-9722     | 密封件冲头     | 1     |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 使用工具 (A) 和适当的压具将毂 (8) 安装在轴组件 (7) 上。
Show/hide table
图 1 | g01358794 |
Show/hide table
图 2 | g01359145 |
公差 |
- 使用工具 (A) 和适当的压具将轴 (7) 安装在壳体 (6) 中。 安装轴组件,使轴承与壳体平齐。
- 使用工具 (B) 和适当的压具将密封件组件 (5) 安装在壳体 (6) 中。 密封件组件 (5) 的工作高度 (C) 为 12.19 ± 0.13 mm (0.480 ± 0.005 in)。
- 使用工具 (A) 和适当的压具将叶轮 (4) 安装在轴组件 (7) 上。 叶轮 (4) 的工作高度 (D) 为 8.97 ± 0.25 mm (0.350 ± 0.010 in)。
- 安装新密封垫 (3) 。
- 放置盖 (2) ,然后安装螺栓 (1) 。
- 放置皮带轮 (9) ,然后安装螺栓 (10) 。 从水泵皮带轮内槽到壳体表面的距离 (E) 应为 136.40 ± 0.300 mm (5.370 ± 0.012 in)。
- 请参阅技术规格, "水泵" 以了解公差。
End By: 安装水泵。 请参阅 拆解和组装, "水泵 - 安装"。
Caterpillar Information System:
Time Zone needs to be Updated on CAESultra{7490, 7604} Time Zone needs to be Updated on CAESultra{7490, 7604}
AP655D and BG655D Asphalt Pavers Engine Crankcase Breather - Clean
AP655D and BG655D Asphalt Pavers Engine Air Filter Service Indicator - Inspect
AP655D and BG655D Asphalt Pavers Propel System Pump Synchronization - Test and Adjust
Differential Housing Components for Wheel Loaders, Articulated Trucks, Wheel Tractors, Compactors, Integrated Toolcarriers, and Motor Graders {3258, 3284} Differential Housing Components for Wheel Loaders, Articulated Trucks, Wheel Tractors, Compactors, Integrated Toolcarriers, and Motor Graders {3258, 3284}
AP655D and BG655D Asphalt Pavers Engine Air Filter Secondary Element - Replace
773D Off-Highway Truck Fuel System - Prime
IT38H Integrated Toolcarrier and 938H Wheel Loader Machine Systems Loader Frame to Rear Frame - Connect
C9.3 Engines for Caterpillar Built Machines Water Pump - Disassemble
450E Backhoe Loader Belt - Inspect/Adjust/Replace
AP655D and BG655D Asphalt Pavers Propel System Piston Pump Neutral - Test and Adjust - Left Propel Pump
AP655D and BG655D Asphalt Pavers Engine Air Cleaner Inlet - Clean
Procedure for Updating the Time Zone on CAESultra 3rd Party Radios{733T, 7490, 7604} Procedure for Updating the Time Zone on CAESultra 3rd Party Radios{733T, 7490, 7604}
Payload Control System (PCS) 2.X Sensors
Payload Control System (PCS) 2.X Calibration
Payload Control System (PCS) 2.X Payload Control System/PC Off-Board System
14L Motor Grader Machine Systems Seat - Remove and Install
773D Off-Highway Truck Power Train Electronic Control Module (Power Train) - Remove and Install
D6K Track-Type Tractor Power Train Track Adjuster - Disassemble
AP655D and BG655D Asphalt Pavers Engine Mounts - Inspect
AP655D and BG655D Asphalt Pavers Engine Oil Level - Check
AP655D and BG655D Asphalt Pavers Engine Oil Sample - Obtain
AP655D and BG655D Asphalt Pavers Engine Oil and Filter - Change
938G Series II Wheel Loader and IT38G Series II Integrated Toolcarrier Plate Locations and Film Locations