Air Compressor - Inspect
注: 关于机器机罩正确升起程序的指南，参见操作和保养手册, "机罩倾斜"。
- 从排出头上拆下接头。 检查排放管中的积碳是否过多。 检查排放头中的积碳是否过多。 清除过多的积碳。 要特别注意进气系统。 要特别注意机油供给。 检查机油回流。 如有必要，修理或更换压缩机。
Show/hide table
 | |
| 图 1 | g01140823 |
- 检查运行期间的压缩机噪音是否过大。 噪声表示连接器磨损。 连接器用于主动齿轮。 更换或调整连接器。
- 检查压缩机的安装螺栓。 均匀地拧紧螺栓。
- 检查有无泄漏。 检查卸荷阀是否工作正常。
- 拔下机罩支撑杆。 关闭发动机室罩。
Caterpillar Information System:
R2900G Load Haul Dump Ride Control Accumulator - Check - If Equipped
C11 and C15 Engines for Caterpillar Built Machines Ether Injection System - Test
AP-1055D and BG-2455D Asphalt Pavers Machine Systems Piston Pump (Left Drag Conveyor and Right Auger Conveyor) - Remove
834H Wheel Dozer and 836H Landfill Compactor Electrohydraulic System MID 082 - CID 1964 - FMI 04
AP500F Asphalt Paver Machine Systems Feeder Drive Shaft Group - Disassemble
PM-201 Cold Planer Moldboard Down Pressure Adjustment
966H and 972H Wheel Loaders Machine Systems Piston Pump (Brake, Hydraulic Fan) - Assemble
966H and 972H Wheel Loaders Machine Systems Piston Pump (Brake, Hydraulic Fan) - Disassemble
PM-201 Cold Planer Daily Inspection
AP-1055D and BG-2455D Asphalt Pavers Machine Systems Piston Pump (Right Drag Conveyor and Left Auger Conveyor) - Install
RM-500 Road Reclaimer/Soil Stabilizer Machine Systems Hydraulic Tank
C15 and C18 Engines for Caterpillar Built Machines Sensors and Electrical Connectors
PM-201 Cold Planer Air Tank - Drain
PM-201 Cold Planer Backup Alarm - Test
834H Wheel Dozer and 836H Landfill Compactor Electrohydraulic System MID 082 - CID 1964 - FMI 08
834H Wheel Dozer and 836H Landfill Compactor Electrohydraulic System MID 082 - CID 1964 - FMI 13
PM-201 Cold Planer Belt Tensioner (Rotor Drive) Idler and Cylinder Ends - Lubricate
R2900G Load Haul Dump Window - Clean - If Equipped
R2900G Load Haul Dump Window Wiper - Inspect/Replace - If Equipped
R2900G Load Haul Dump Capacities (Refill)
R2900G Load Haul Dump Lubricant Viscosities
R2900G Load Haul Dump Braking System Solenoid Valve (Parking Brake) - Test
PM-201 Cold Planer Belt Tensioner (Rotor Drive) Pulley - Lubricate
2005/06/13 The Load Control Valve (Drift Reduction Valve) for the Boom Is Improved {5067, 5117, 5147, 5811}